Accumulation of 1-deoxynojirimycin in silkworm, Bombyx mori L.

Accumulation of 1-deoxynojirimycin in silkworm, Bombyx mori L. 1 2 first-author 1 1 1 1 1 1 corresp ‡Corresponding Author ‡Corresponding Author †E-mail:wzcui88@163.comwuxiaofeng@zju.edu.cn †E-mail:wzcui88@163.comwuxiaofeng@zju.edu.cn wzcui88@163.com 3 corresp ‡Corresponding Author ‡Corresponding Author †E-mail:wzcui88@163.comwuxiaofeng@zju.edu.cn †E-mail:wzcui88@163.comwuxiaofeng@zju.edu.cn wzcui88@163.com Key Laboratory of Agricultural Ecology and Environment, College of Forestry, Shandong Agricultural University, Taian 271018, China Key Laboratory of Agricultural Ecology and Environment, College of Forestry, Shandong Agricultural University, Taian 271018, China Institute of Sericultural Sciences of Sichuan Province, Nanchong 637000, China Institute of Sericultural Sciences of Sichuan Province, Nanchong 637000, China College of Animal Science, Zhejiang University, Hangzhou 310029, China College of Animal Science, Zhejiang University, Hangzhou 310029, China 1-deoxynojirimycin (1-DNJ) contents in the silkworm, Bombyx mori , at different developmental stages and tissues were investigated by using reverse-phase high-performance liquid chromatography. The 1-DNJ contents of silkworm larvae change significantly with their developmental stages. The male larvae showed higher accumulation efficiency of 1-DNJ than the females and also a significant variation was observed among the silkworm strains. The present results show that tissue distribution of 1-DNJ was significantly higher in blood, digestive juice, and alimentary canal, but no 1-DNJ was observed in the silkgland. Moreover, 1-DNJ was not found in silkworms fed with artificial diet that does not contain mulberry leaf powder. This proves that silkworms obtain 1-DNJ from mulberry leaves; they could not synthesize 1-DNJ by themselves. The accumulation and excretion of 1-DNJ change periodically during the larval stage. There was no 1-DNJ in the newly-hatched larvae and 1-DNJ was mainly accumulated during the early and middle stages of every instar, while excreted at later stages of larval development. Further, it is possible to extract 1-DNJ from the larval feces and it is optimal to develop the 1-DNJ related products for diabetic auxiliary therapy. Silkworm 1-deoxynojirimycin (1-DNJ) Accumulation Bombyx mori Introduction 1 Nojirimycin was firstly discovered from streptomycete. 1-deoxynojirimycin (1-DNJ) is the product of nojirimycin through hydrogenation. The natural DNJ was firstly isolated from mulberry tree (Yoshikaki and Hivonu, 1976 1976 ), and up to now more than 20 of polyhydroxy alkaloids were identified from mulberry and silkworm (Asano et al., 1994a 1994a ; 1994b 1994b ; 2001 2001 ). As a piperidine alkaloid, DNJ is known as a highly effective α-glycosidase inhibitor (Yoshikuni, 1988 1988 ; Yoshikuni et al., 1988 1988 ; Hughes and Rudge, 1994 1994 ), and is one of the effective chemicals for anti-hyperglycemia. Presently DNJ and its analogs have been abstracted from a wide range of plants and microbes (Asano et al., 1998 1998 ; 2000 2000 ; Kim et al., 1999 1999 ), but the DNJ contents in mulberry tree are the highest compared with other plants (Kimura et al., 2007 2007 ; Yatsunami et al., 2008 2008 ). Mulberry has been utilized as Chinese medicine against diabetes mellitus for long time. Ryu et al. ( 1997 1997 ) firstly reported that the silkworm larval powder of the 5th instar (prepared by lyophilization) had a good effect on diabetic patients (Ryu et al., 1997 1997 ; 1999 1999 ), and the effect for lowering the blood sugar level was further proved by subsequent research (Han et al., 2007 2007 ). Recently in Korea, Japan, and China these related products made of mulberry and silkworm larvae are popular for auxiliary therapy on diabetes mellitus. The silkworm powder has higher DNJ content than mulberry, indicating that the larvae can accumulate and enrich DNJ from mulberry leaves (Kim et al., 2003 2003 ), and thereby the larval powder displays more effective results on diabetic. However, it is unknown whether the silkworm itself synthesizes DNJ, and little is known about assimilation, enrichment, and excretion of DNJ in silkworm, as well as the factors affecting the DNJ accumulation. Our study provides a basis for the DNJ enrichment and excretion in the silkworm, which may play an active role for preparing DNJ-related products. Materials and methods 1 Materials 2 Silkworm larvae were reared by feeding fresh mulberry leaves or artificial diet at 25 °C. Artificial diets were prepared (Table 1 1 ), and six types of diets containing various percentages of mulberry leaf powder were used. The dry diets were mixed with two-fold water and autoclaved. VB mixture consists of cyclohexanhexol, becholine, calcium pantothenate, niacin, benadon, riboflavin, aneurin hydrochloride, bioepiderm, and acidum folicum Inorganic salt mixture contains K 2 HPO 4 ·3H 2 O, CaCO 3 , KCl, MgSO 4 ·7H 2 O, and FeSO 4 ·7H 2 O Group Mulberry leaf powder (%) Bean powder (%) Maize powder (%) Citric acid (%) Gallic acid (%) Sorbic acid (%) Vitamin C (%) VB mixture (%) a a Inorganic salt mixture (%) b b 1 0 20.0 74.4 2.5 0.5 0.3 1.0 0.3 1.0 2 10.0 20.0 64.4 2.5 0.5 0.3 1.0 0.3 1.0 3 20.0 20.0 54.4 2.5 0.5 0.3 1.0 0.3 1.0 4 30.0 20.0 44.4 2.5 0.5 0.3 1.0 0.3 1.0 5 40.0 20.0 34.4 2.5 0.5 0.3 1.0 0.3 1.0 6 50.0 20.0 24.4 2.5 0.5 0.3 1.0 0.3 1.0 DNJ measurement 2 For DNJ analysis, the silkworm larvae were collected after starvation for 24 h, and the samples were lyophilized, smashed, and passed through a 100-mesh screen. The artificial diets and mulberry leaves were dried under 60 °C, grounded, and passed through a 100-mesh screen. DNJ content was measured according to the method reported by Kim et al. ( 2003 2003 ). DNJ in the silkworm larva or mulberry leaf powder was extracted with 0.05 mol/L HCl, treated with 9-fluorenylmethyl (FMOC) in pH 8.5 borate buffer solution to produce DNJ-FMOC complex compound, and finally detected by ultraviolet-reverse-phase high-performance liquid chromatography (UV-RP-HPLC). Data analysis 2 All the data were treated by statistical analysis applying to SAS 9.0 DA software. The absorption and enrichment of DNJ in silkworm larvae were calculated by the following formulas: R a (%)= M 1 / M 2 ×100, where R a is the absorption ratio of DNJ during 1st to 4th instar or every day of the 5th instar, M 1 is the increased DNJ amount in body at every instar or every day of the 5th instar, and M 2 is the DNJ amount ingested at that instar or that day of the 5th instar; R e (%)= M 3 / M 4 ×100, where R e is the accumulated enrichment ratio of DNJ by larvae, M 3 is the DNJ amount in larvae, and M 4 is the accumulated DNJ amount ingested. Results 1 Relationship between DNJ contents in diets and in larvae 2 The silkworm larvae were fed with artificial diets varying with different contents of mulberry leaf powder or fresh mulberry leaves. The DNJ contents of artificial diets and the larvae of the 3rd day in the 5th instar were measured, and are presented in Table 2 2 . The chromatograms of silkworm DNJ are shown in Fig. 1 1 . The results show that the DNJ content in the artificial diets depended on the content of mulberry leaf powder. No DNJ could be detected in the diet without mulberry powder, implying that mulberry powder was the sole source for DNJ. In the larvae, the DNJ content increased with the amount of DNJ in the diets. Statistical analysis demonstrated that there was a closely positive and linear relationship between the DNJ content in the diets ( X ) and the one in the larval body ( Y ) when euryphagous or general silkworm race was tested: Y =7.2111 X +0.0232, R 2 =0.9154 (Group 1, a euryphagous silkworm Guangshi); Y =5.2633 X +0.0129, R 2 =0.9526 (Group 2, general hybrid silkworm Guangshi×Fengyi). No DNJ was detected in the larvae raised with artificial diets without mulberry leaf powder, indicating that the larva could not synthesize DNJ by itself. A euryphagous silkworm race, Guangshi, was used General hybrid silkworm race was used, commercial name: Guangshi×Fengyi Mulberry leaf powder content in artificial diets (%) DNJ content in artificial diets (%) DNJ content in euryphagous silkworm (%) a a DNJ content in general hybrid silkworm (%) b b 0 0 0 0 10 0.0148±0.0005 0.1862±0.0022 0.1244±0.0060 20 0.0333±0.0004 0.2062±0.0128 0.1670±0.0049 30 0.0363±0.0004 0.2984±0.0203 0.1906±0.0019 40 0.0439±0.0006 0.3228±0.0006 0.2380±0.0075 50 0.0482±0.0010 0.3982±0.0257 0.2863±0.0033 Fresh leaves 0.0918±0.0028 0.5706±0.0142 0.4608±0.0001 (a) Chromatogram of separation of DNJ standard solution; (b) Chromatogram of separation of mulberry powder solution; (c) Chromatogram of separation of silkworm powder solution. 1-GLY-FMOC: 1-glycine-fluorenyl-methyl chl-oroformate Variation of DNJ accumulation between male and female silkworm larvae 2 The results show that the DNJ content in male larvae was relatively higher than that in the females. There was a significant increase in DNJ content in both sexes when the larvae were fed with Nongsang 14 over Dajiguan and Husang 32 mulberry varieties (Table 3 3 ). The present results show that the male larvae could absorb and accumulate DNJ from diets more efficiently than females. Silkworm variety: Chunlei×Zhenzhu The larvae of 3rd day in 5th instar were tested 2 Morus species 2 DNJ content in mulberry leaf powder (%) 2 DNJ content in larval powder (%) Female Male  Nongsang 14 0.121±0.025 0.371±0.007 0.465±0.018  Dajiguan 0.116±0.010 0.286±0.032 0.341±0.006  Husang 32 0.107±0.060 0.257±0.010 0.316±0.036 DNJ accumulation among silkworm varieties 2 The DNJ contents among various silkworm varieties were investigated (Fig. 2 2 ). The results show that there was a significant difference in DNJ content among various silkworm varieties. Among the races, the larvae of Jingsong showed a relatively high content of DNJ (0.375%), and a lower one was observed in hybrid silkworm 973×974. Silkworm varieties: 1, Jingsong; 2, Chunlei×Zhenzhu; 3, Luqi; 4, Haoyue; 5, 9202×Luqi; 6, 9202; 7, Luhuang; 8, Jingsong×Haoyue; 9, 973×974. DNJ was measured using the larvae of the 3rd day in the 5th instar. Each value is the mean±SE of replications Distribution of DNJ in larval organs or tissues 2 As silkworm variety Zhg×Chun 54 is the most popular and a commercial variety in production, this variety has better characteristics, such as a big body and being easy to raise for a large scale. Considering a medical use in the future, we chose this variety for the current study, except specially indicated. The distribution of DNJ in the larval body was investigated, and the results (Fig. 3 3 ) show that, except the silk gland, all organs and tissues contained DNJ. Among the tissues, there was a significant increase in DNJ content in blood, followed by intestinal juice and alimentary canal. DNJ was measured using the larvae of the 3rd day in the 5th instar. Larval organs or tissues: 1, blood; 2, intestinal juice; 3, alimentary canal; 4, Malpighian tubule; 5, midgut peritrophic membrane; 6, cuticles; 7, body wall; 8, fat body; 9, trachea; 10, silk gland DNJ content in mulberry leaf during growing stage 2 The DNJ contents in mulberry leaves of various growing stages were analyzed and are present in Fig. 4 4 . The DNJ content was relatively high in tender leaves and decreased as the leaves matured into the medium-sized and coarse ones. Mulberry variety: Nongsang 14. Growing days refer the day order since the sprouting Accumulation and excretion of DNJ during larval stages 2 The results showed that the newly-hatched silkworm contained no DNJ, and then the DNJ content gradually increased until the middle of every instar, and then gradually decreased. The DNJ contents in the molting larvae were relatively low than that in the feeding larvae. The DNJ contents were sharply decreased from the 3rd or 4th day of the 5th instar, and no DNJ could be detected in the mature larvae. DNJ content in the larval feces changed significantly during the growth period (Fig. 5 5 ). A significant increase in the DNJ content was observed during the 4th instar in feces over the other instars. In the 5th instar, the DNJ contents were stable for the first three days, and increased in the following two days and reached the peak one day before maturing larvae. Stage of development: 1, newly-hatched larva; 2, 3rd day of 1st instar; 3, molting stage of 1st instar; 4, larva in the middle of 2nd instar; 5, molting larva of 2nd instar; 6, larva in the middle of 3rd instar; 7, molting larva of 3rd instar; 8, larva in the middle of 4th instar; 9, molting larva of 4th instar; 10, 1st day of 5th instar; 11, 2nd day of 5th instar; 12, 3rd day of 5th instar; 13, 4th day of 5th instar; 14, 5th day of 5th instar; 15, 6th day of 5th instar; 16, 7th day of 5th instar; 17, mature larvae Based on the above results, it was noticed that DNJ contents in the larvae and the feces changed periodically and there was a close relationship of DNJ contents between the larvae and feces. DNJ content increased in larvae during the early and middle stages of every instar, while decreased during later stages, i.e., molting and mature larval stages. The present results indicate that early and middle instars were the main stages for DNJ accumulation in larvae, while at later stages DNJ content was mostly excreted and increased in the feces. The data of DNJ ingestion and accumulation in the larvae are presented in Table 4 4 . The results show that the total DNJ content ingested during the whole larval stage was 9625 μg. DNJ accumulation in larval body reached the maximum on the 5th day of the 5th instar, and every larva contained 1825 μg of DNJ. From the 6th day of the 5th instar, no DNJ was observed in silkworm larvae; i.e., it was excreted. The absorption ratio on DNJ was higher on the 1st to 3rd days of the 5th instar, and the highest (44.41%) on the 2nd day. The accumulation ratio reached the peak on the 3rd day of the 5th instar by 33.80%. Every instar and every day of the 5th instar Ingested DNJ (μg/larva) Cumulative ingested DNJ (μg/larva) DNJ content in larva (μg/larva) Increased DNJ in larva (μg/larva) Absorption ratio (%) Cumulative enrichment ratio (%) Newly hatched 0.00 0.00 1st instar 17.19 17.19 3.11 3.11 18.09 18.09 2nd instar 66.48 83.67 17.49 14.38 21.63 20.90 3rd instar 272.21 355.88 96.54 79.05 29.04 27.13 4th instar 1416.80 1772.68 379.14 282.60 19.95 21.39 Day 1, 5th instar 367.12 2139.80 537.54 158.40 43.15 25.12 Day 2, 5th instar 717.85 2857.65 856.37 318.83 44.41 29.97 Day 3, 5th instar 1279.99 4137.64 1398.65 542.28 42.36 33.80 Day 4, 5th instar 1211.22 5348.86 1643.24 244.59 20.19 30.72 Day 5, 5th instar 1365.08 6713.94 1825.46 182.22 13.35 27.19 Day 6, 5th instar 1392.66 8106.60 1815.85 −9.61 −0.69 22.40 Day 7, 5th instar 1060.13 9166.73 1037.01 −778.84 −73.47 11.31 Day 8, 5th instar 457.84 9624.57 631.74 −405.27 −88.52 6.56 Mature larva 0.00 9624.57 0.00 −631.74 0.00 Discussion and conclusion 1 There are many reports on the DNJ in Morus , and it was found that DNJ contents in mulberry leaves were affected by many factors, such as Morus species and seasons (Kimura et al., 2007 2007 ; Yatsunami et al., 2008 2008 ). However, almost no studies were done in the silkworm, and DNJ accumulation and excretion in the larva are not clear. This investigation showed that DNJ in the silkworm was ingested from diets, and its contents depended on the DNJ content in the diets, indicating that a silkworm larva could not synthesize DNJ by itself. Our results indicate that the accumulation of DNJ in the larvae was affected by the sex, varieties, and developing stages of silkworms. The male larvae can accumulate DNJ more efficiently than the females. DNJ accumulation and excretion in the larvae were periodically changed. We conclude that it is the most effective and economic to develop DNJ-related products by using the male larvae of the 3rd day of the 5th instar, fed with leaves containing higher DNJ. In addition, the feces of silkworms before ecdysis and mature stage contain higher DNJ content and it can also be a resource for DNJ extraction. References N Asano , E Tomioka , H Kizu , K Oseki , K Matsui . Sugars with nitrogen in the ring isolated from the leaves of Morus bombycis . Carbohydr Res , 1994 . 253 ( 3 ): 235 - 245 . 8156550 DOI: 10.1016/0008-6215(94)80068-5 http://doi.org/10.1016/0008-6215(94)80068-5 . Sugars with nitrogen in the ring isolated from the leaves of Morus bombycis N Asano , K Oseki , E Tomioka , H Kizu , K Matsui . N-containing sugars from Morus alba and their glycosidase inhibitory activities . Carbohydr Res , 1994 . 259 ( 2 ): 243 - 255 . 8050098 DOI: 10.1016/0008-6215(94)84060-1 http://doi.org/10.1016/0008-6215(94)84060-1 . N-containing sugars from Morus alba and their glycosidase inhibitory activities N Asano , A Kato , M Miyauchi , H Kizu , Y Kameda , AA Watson , RJ Nash , GW Fleet . Nitrogen-containing furanose and pyranose analogues from Hyacinthus orientalis . J Nat Prod , 1998 . 61 ( 5 ): 625 - 628 . 9599261 DOI: 10.1021/np9705726 http://doi.org/10.1021/np9705726 . Nitrogen-containing furanose and pyranose analogues from Hyacinthus orientalis N Asano , M Nishida , M Miyauchi , K Ikeda , M Yamamoto , H Kizu , Y Kameda , AA Watson , RJ Nash , GW Fleet . Polyhydroxylated pyrrolidine and piperidine alkaloids from Adenophora triphylla var. japonica (Campanulaceae) . Phytochemistry , 2000 . 53 ( 3 ): 379 - 382 . 10703061 DOI: 10.1016/S0031-9422(99)00555-5 http://doi.org/10.1016/S0031-9422(99)00555-5 . Polyhydroxylated pyrrolidine and piperidine alkaloids from Adenophora triphylla var. japonica (Campanulaceae) N Asano , T Yamashita , K Yasuda , K Ikeda , H Kizu , Y Kameda , A Kata , RJ Nash , HS Lee , KS Ryu . Polyhydroxylated alkaloids isolated from mulberry trees ( Morus alba L.) and silkworms ( Bombyx mori L.) . J Agric Food Chem , 2001 . 49 ( 9 ): 4208 - 4213 . 11559112 DOI: 10.1021/jf010567e http://doi.org/10.1021/jf010567e . Polyhydroxylated alkaloids isolated from mulberry trees (Morus alba L.) and silkworms (Bombyx mori L.) J Han , S Inoue , H Isoda . Effects of silkworm powder on glucose absorption by human intestinal epithelial cell line Caco-2 . J Nat Med , 2007 . 61 ( 4 ): 387 - 390 . DOI: 10.1007/s11418-007-0164-5 http://doi.org/10.1007/s11418-007-0164-5 . Effects of silkworm powder on glucose absorption by human intestinal epithelial cell line Caco-2 AB Hughes , AJ Rudge . Deoxynojirimycin: synthesis and biological activity . Nat Prod Rep , 1994 . 11 ( 2 ): 135 - 162 . 15209127 DOI: 10.1039/np9941100135 http://doi.org/10.1039/np9941100135 . Deoxynojirimycin: synthesis and biological activity HS Kim , YH Kim , YS Hong , NS Paek , HS Lee , TH Kim , KW Kim , JJ Lee . Alpha-glucosidase inhibitors from commelina communis . Planta Med , 1999 . 65 ( 5 ): 437 - 439 . 10418330 DOI: 10.1055/s-2006-960803 http://doi.org/10.1055/s-2006-960803 . Alpha-glucosidase inhibitors from commelina communis JW Kim , SU Kim , HS Lee , I Kim , MY Ahn , KS Ryu . Determination of 1-deoxynojirimycin in Morus alba L. leaves by derivatization with 9-fluorenylmethyl chloroformate followed by reversed-phase high-performance liquid chromatography . J Chromatogr A , 2003 . 1002 ( 1-2 ): 93 - 99 . 12885082 DOI: 10.1016/S0021-9673(03)00728-3 http://doi.org/10.1016/S0021-9673(03)00728-3 . Determination of 1-deoxynojirimycin in Morus alba L. leaves by derivatization with 9-fluorenylmethyl chloroformate followed by reversed-phase high-performance liquid chromatography T Kimura , K Nakagawa , H Kubota , Y Kojima , K Yamaqishi , S Oita , S Oikawa , T Miyazawa . Food-grade mulberry powder enriched with 1-deoxynojirimycin suppresses the elevation of postprandial blood glucose in humans . J Agric Food Chem , 2007 . 55 ( 14 ): 5869 - 5874 . 17555327 DOI: 10.1021/jf062680g http://doi.org/10.1021/jf062680g . Food-grade mulberry powder enriched with 1-deoxynojirimycin suppresses the elevation of postprandial blood glucose in humans KS Ryu , HS Lee , SH Chung , PD Kang . An activity of lowering blood-glucose levels according to preparative condition of silkworm powder . Kor J Seric Sci , 1997 . 39 ( 1 ): 79 - 85 . . An activity of lowering blood-glucose levels according to preparative condition of silkworm powder KS Ryu , HS Lee , SY Kim . Pharmacodynamic study of silkworm powder in mice administered to maltose, sucrose and lactose . Kor J Seric Sci , 1999 . 41 ( 1 ): 9 - 13 . . Pharmacodynamic study of silkworm powder in mice administered to maltose, sucrose and lactose K Yatsunami , M Ichida , S Onodera . The relationship between 1-deoxynojirimycin content and alpha-glucosidase inhibitory activity in leaves of 276 mulberry cultivars ( Morus spp.) in Kyoto . Jpn Nat Med (Tokyo) , 2008 . 62 ( 1 ): 63 - 66 . . The relationship between 1-deoxynojirimycin content and alpha-glucosidase inhibitory activity in leaves of 276 mulberry cultivars (Morus spp.) in Kyoto A Yoshikaki , M Hivonu . The structure of moranoline, a piperidine alkaloid form Morus species . Nippon Nogei Kagaku Kaishi , 1976 . 50 ( 11 ): 571 - 572 . . The structure of moranoline, a piperidine alkaloid form Morus species Y Yoshikuni . Inhibition of intestinal alpha-glucosidase activity and postprandial hyperglycemia by moranoline and its N -alkyl derivatives . Agric Biol Chem , 1988 . 52 ( 1 ): 121 - 128 . . Inhibition of intestinal alpha-glucosidase activity and postprandial hyperglycemia by moranoline and its N-alkyl derivatives Y Yoshikuni , Y Ezure , Y Aoyagi , H Enomoto . Inhibition of intestinal alpha-glucosidase and postprandial hyperglycemia by N -substituted moranoline derivatives . J Pharmacobiodyn , 1988 . 11 ( 5 ): 356 - 362 . 2971794 . Inhibition of intestinal alpha-glucosidase and postprandial hyperglycemia by N-substituted moranoline derivatives 10.1631/jzus.B0900344 2009-10-30 2010-03-05 2010-02-01 2022-01-05 Copyright © Zhejiang University and Springer-Verlag Berlin Heidelberg 2010 2010 Journal of Zhejiang University-SCIENCE B (Biomedicine and Biotechnology) 04 11