Study on US/O₃ mechanism in p-chlorophenol decomposition

Study on US/O 3 mechanism in p -chlorophenol decomposition first-author †E-mail:xxw118@zju.edu.cn †E-mail:xxw118@zju.edu.cn xxw118@zju.edu.cn Department of Environmental Science and Engineering, Zhejiang University, Hangzhou 310027, China Department of Environmental Science and Engineering, Zhejiang University, Hangzhou 310027, China Study on the effects of sonolysis, ozonolysis and US/O 3 system on the decomposition of p -chlorophenol in aqueous solutions indicated that in the cases of US/O 3 system, individual ozonolysis and sonolysis, the decomposition rate of p -chlorophenol reached 78.78%, 56.20%, 2.79% after a 16-min reaction while its CODcr (chemical oxygen demand) removal rate was 97.02%, 62.17%, 3.67% after a 120-min reaction. The decomposition reaction of p -chlorophenol follows pseudo-first-order kinetics. The enhancement factors of p -chlorophenol and its COD cr under US/O 3 system reached 63% and 237% respectively. The main intermediates during the decomposition include catechol, hydroquinone, p -benzoquinone, phenol, fumaric acid, maleic acid, oxalic acid and formic acid. The decomposition mechanism of p -chlorophenol was also discussed. US/O 3 p -chlorophenol Synergetic effect Decomposition mechanism INTRODUCTION 1 Due to its high oxidability, high reaction rate and absence of any secondary pollution, ozonolysis technique has increasingly been used in the sanitization of drinking water, treatment of industrial wastewater and especially in the treatment of pollutants which are difficult to get rid of in biological oxidation processes. Its low dispersion rate and high cost, however, impede it from wider applications. In recent years, in order to improve the utilization rate of ozone, several groups have made some advances in combing ozonolysis technique with other methods, including advanced oxidization processes (AOPs) such as UV/O 3 , H 2 O 2 /O 3 , H 2 O 2 /UV/O 3 , US/O 3 (Staehelin and Hoigné, 1982 1982 ; Adams et al., 1994 1994 ; Peyton and Glaze, 1988 1988 ; Mokrini et al., 1997 1997 ; Guittoneau et al., 1990 1990 ; Sierka and Amy, 1985 1985 ), among which US/O 3 has been proved to be an effective one. According to Destaillats et al.( 2000 2000 ), the removal rate of TOC (total organic carbon) in azobenzene solution, under 500 kHz, could be raised from 20% to 80% in the presence of O 3 . According to Dahi ( 1976 1976 ), sonolysis alone could not get rid of rhodamine B, while the combination of sonolysis and ozonolysis could raise its degradation rate to grade 0.5, 55% higher than that using ozonolysis alone. And according to Olson and Baraier ( 1994 1994 ), the removal rate of fulvic acid in wastewater using US/O 3 was much higher than that using ozonolysis alone. Under the condition of 55 W, 20 kHz, sonolysis and continuous ozone instillation, after 10 min of reaction, 91% of TOC in 10 mg/L fulvic acid solution was removed in which 87% was completely mineralized. In comparison, with ozonolysis alone, TOC removal rate only reached 40% and only 28% was completely mineralized. And according to Kang and Hoffmann ( 1998 1998 ), under the conditions of 205 kHz, 200 W/L, as the initial concentration of MTBE (methyl tert-butyl ether) dropped from 1.0 mmol/L to 0.01 mmol/L, its decomposition rate increased from 4.1×10 −4 s −1 to 8.5×10 −4 s −1 , 1.5~3.9 times more than the original rate. However, the degradation of contaminants by US/O 3 technique had mostly been carried out in laboratory settings so far, and its practical applications are far from being realized. Because of its wide existence in wastewater from dyeing, paper-making, etc. and difficult decomposition by biological means, p -chlorophenol is one of 129 key pollutants which are under strict control by the American Environment Protection Bureau. In this paper, p -chlorophenol is used as the model pollutant, and study of the efficiency of different techniques such as sonolysis, ozonolysis and US/O 3 on its decomposition showed that there was a synergetic effect of US/O 3 system on the decomposition of p -chlorophenol. The p -chlorophenol decomposition mechanism under US/O 3 system was discussed. EXPERIMENTAL METHODS 1 Chemicals 2 Potassium indigotrisulfonate (USA), p -chlorophenol ( > 99.0%, CP), hydroquinone ( > 98.0%, AR), p -benzoquinone ( > 98.5%, CP), catechol ( > 98.0%, CP), phenol ( > 99.9%, AR), fumaric acid ( > 99.0%, CP), maleic acid ( > 99%–101%, CP), oxalic acid ( > 99.5%, AR), Na 2 S 2 O 3 , NaOH, H 3 PO 4 and other reagents were analytical grade. These reagents except potassium indigotrisulfonate were purchased from Shanghai Chemical Reagents Company. Sonochemical experiments 2 Experiments were carried out in a made by us 200 ml glass jacket reactor in the bottom of which was a glass gas diffuser. The top of the reactor had five openings providing connections to a thermometer, a pipette for sampling, an ultrasonic probe head, and a tube each for feeding and venting the gas. A horn type ultrasonic transducer (made by Acoustics Institute of the Chinese Academy of Sciences) at 22 kHz with an active acoustic vibration diameter of 20 mm generated ultrasonic irradiations. The ultrasonic probe head was positioned about 2–3 cm below the surface of the solution with temperature regulated through a jacket circulation of fixed-temperature water in the outside cistern, while ozone was produced through a 3A ozone producer (Product of Hangzhou Rongxin Electronic Equipment Co. Ltd.). First, a certain amount of p -chlorophenol solution was injected into the reactor and the ozone producer was opened. Then, in order to stabilize the gaseous O 3 concentration, we maintained the gross amount of O 3 but diverted some outside and instilled the rest into the reaction solution through the gas diffuser. In the meantime, the ultrasonic transducer was turned on. In experiments on ozonolysis alone, this step was unnecessary and skipped. Samples were taken at regular intervals. Every time we took 2.0-ml samples except for measuring COD cr alone, which was increased to 5 ml. The pH was adjusted with phosphoric acid and sodium hydroxide and the ionic strength was around 0.1 mol/L. In individual sonolysis experiments, O 2 was instilled till saturation in the solution, then ultrasonic irradiation was introduced. Fixed amounts of Na 2 S 2 O 3 were added into the samples to remove the remnant O 3 . Unless discussed otherwise, the experiments were typically carried out under the following conditions: initial mass concentration of p -chlorophenol solution: 46.22 mg/L (COD cr being around 74 mg/L), solution temperature: 25 °C, pH value of the solution: 3, ionic strength: 0.1 mol/L, O 3 /O 2 flow rate: 40 ml/min, gaseous ozone mass concentration: 20.11 mg/L and ultrasonic power generation of transducer: 125 W. To analyze the possible stripping of p -chlorophenol in the oxidation, a separate experiment of only oxygen without ultrasound was carried out. Measurements made before and after the experiment did not show significant change in the concentration of p -chlorophenol. Analysis 2 High-performance liquid chromatograph (HPLC, Shimadzu) was employed to analyze p -chlorophenol and its intermediates. Twenty-five ml aliquots of samples were injected into the HPLC. A mobile phase of phosphate buffer solution (pH=2)/methanol at 70/30 (v/v) was used for determining p -chlorophenol and its intermediates. The separation was performed using an ODS–18 reversed phase column at a flow rate of 1.0 ml/min and a column temperature of 25 °C. A UV detector with the wavelength set at 280 nm was used. Organic acid and chloride produced was determined by ion chromatograph (Metrohm 792 Basic IC). The ozone gas phase concentration was determined by standard methods (EPA, 1989 1989 ). The concentration of ozone in the solution was determined by the indigo method (Bader and Hoigné, 1981 1981 ). Analysis of the COD cr was carried out using a titrimetric method (Xi et al., 1989 1989 ). The removal rate enhancement could be expressed by the promoting factor f defined as: f =[ k US/O 3 /( k US/O 2 + k O 3 )−1]×100% , where, k US/O 3 , k US/O 2 , and k O 3 represent the reaction rate constant in the sonolysis-ozonolysis process, sonolysis process and ozonolysis process, respectively. RESULTS AND DISCUSSIONS 1 Comparison of the decomposition effects under different systems 2 Fig. 1 1 shows the decomposition of 46.22 mg/L p -chlorophenol and its COD cr using different treatment systems, i.e., individual sonolysis, individual ozonlysis and US/O 3 . It was evident that US/O 3 was the most effective system for decomposing p -chlorophenol, while individual sonolysis was the least effective one. The p -chlorophenol decomposition after 16-min reaction was determined to be 78.78%, 56.20% and 2.79% under US/O 3 , individual ozonolysis and individual sonolysis respectively, COD cr decomposition rate reached 97.02%, 62.17% and 3.67% after 120-min reaction. Since the COD cr decomposition rate appeared to be distinctly lower than that of p -chlorophenol, it was possible that a series of intermediates were produced during the oxidization process of p -chlorophenol; these intermediates were later mineralized into organic acid, CO 2 and H 2 O. Decomposition kinetics 2 As shown in Fig. 2 2 , it was found that the decomposition using the above three approaches fit in the following pseudo-first-order kinetics: ln( c 0 / c )= kt where, c 0 and c are the initial mass concentration of p -chlorophenol or COD cr (mg/L) at the reaction time t , respectively; k is the pseudo-first-order reaction rate constant (min −1 ) obtained by least square analysis, the linear regression equation is y =m x +b. The simulated reaction rate constants are listed in Table 1 1 . Processes k for p -chlorophenol (10 2 min −1 ) k for COD cr (10 2 min −1 ) US/O 2 0.231±0.002 0.0299±0.001 O 3 7.291±0.353 0.800±0.007 US/O 3 12.25±0.519 2.799±0.234 It was evident that in comparison with the individual sonolysis or ozonolysis, the combined process had synergetic effects in enhancing the removal rate of both p -chlorophenol and COD cr . k for p -chlorophenol removal. For example, in the combined process (0.1225±0.00519 min −1 ) the removal rate was much greater than that obtained by the addition of the value of k obtained in the individual sonolysis process (0.00231±0.00002 min −1 ) and in the individual ozonolysis process (0.07291±0.00353 min −1 ). The enhancement factor f was estimated to be about 63%. Similarly, the COD cr removal rate enhancement factor was as high as 237%, much greater than that of the p -chlorophenol. The result indicated that the evolution of intermediates during p -chlorophenol decomposition was significantly accelerated in the combined process. It was concluded that the enhancement factors f we obtained under O 3 , US and US/O 3 systems were similar to those in the references (Destaillats et al., 2000 2000 ; Kang and Hoffmann, 1998 1998 ; Olson and Baraier, 1994 1994 ) and that US/O 3 is an efficient oxidation technology. Decomposition mechanism 2 During acoustic cavitation, water is pyrolytically decomposed leading to the formation of hydroxyl and hydroperoxyl radicals as follows: H 2 O→H·+·OH H·+O 2 →HO 2 · In the bulk aqueous phase, ozone could be decomposed by OH − , or the conjugate base of H 2 O 2 (HO 2 − ) to yield HO 2 · and ·OH as shown below: O 3 +OH − →HO 2 − +O 2 HO 2 − +H + →H 2 O 2 O 3 +HO 2 − →O 2 − +·OH+O 2 O 2 − +H + →HO 2 · O 3 +·OH→O 2 +HO 2 · O 3 +O 2 − →O 3 − +O 2 O 3 − +H 2 O→OH − + ·OH+O 2 The coupling of sonolysis with ozonolysis augments ·OH due to the decomposition of ozone. Ozone is decomposed thermolytically in the vapor phase of a cavitation bubble as follows (Hart and Henglein, 1986 1986 ): O 3 →O+O 2 The initial reaction yields atomic oxygen which reacts with water to form hydroxyl radical and hydrogen peroxides are produced subsequently as follows: O+H 2 O→2·OH 2·OH→H 2 O 2 Based on the above analysis, it could be well established that the combination of sonolysis and ozonolysis is a much more effective oxidation system than either alone since two ·OH are formed per O 3 molecule consumed. Therefore, the coupling of sonolysis with ozonolysis provides more ·OH due to the decomposition of ozone which partly accounts for the synergetic effects. p -chlorophenol and its byproducts can be directly pyrolysed in the cavitation bubble itself or its interfacial sheath, react with ozone and one of the active species generated by the combined sonolysis of water and ozone. Theoretically, in p -chlorophenol solution with initial concentration of 46.22 mg/L, the chlorine group is 12.78 mg/L. In order to explore the decomposition mechanism of p -chlorophenol using US/O 3 approach, the change of Cl − mass concentration was measured. Fig. 3 3 shows that after 6-min reaction, the removal rate of p -chlorophenol was 36.24%, which means that although in theory Cl − mass concentration is 4.63 mg/L, it is actually 4.52 mg/L in practice or 97.62% of the former; while after 36 min, the removal rate of p -chlorophenol reaches 99.68%, that is, in theory, Cl − concentration is 12.73 mg/L, compared with 12.49 mg/L in practice or 98.11% of the former. In view of unavoidable experimental errors, it can be inferred that chlorine is the first group removed in the decomposition process of p -chlorophenol. Through HPLC and IC, catechol, hydroquinone, p -benzoquinone, phenol, fumaric acid, maleic acid, oxalic acid and formic acid were detected as the intermediates of p -chlorophenol decomposition (HPLC spectra shown in Fig. 4 4 ) among which hydroquinone and p -benzoquinone were the most concentrated. Fig. 5 5 indicates the mass concentration changes of hydroquinone, p -benzoquinone and catechol. At the initial stage, the mass concentration of hydroquinone increases quickly and after 8 min, reaches its maximum (2.49 mg/L), and finally decreases to 0 after 50 min. While p -benzoquinone reaches its maximum mass concentration (12.41 mg/L) and after 10 min, the reaction becomes much slower. As a result, little catechol is produce, and its maximum mass concentration reaches only 0.31 mg/L, stopped there after 25 min. A: Phenol; B: p -chlorophenol; C: Catechol; D: p -benzoquinone; E: Hydroquinone; F: Fumaric acid; G: Maleic acid; H: Oxalic acid It can be derived from the experiments results that, p -chlorophenol decomposition can be divided into three stages: first, no matter whether it is in thermo-decomposition at cavitation bubble interfacial sheath or in reaction of O 3 and ·OH, it was the chlorine groups that were first removed, which resulted in phenol. Second, though the hydroxyl group is an electron density-enhancing substituent whose inductive effect and conjugative effect result in the ortho and/or para positions having higher electron density than the hydroxyl group; the electrophilic reaction favors a high electron density position with the phenol molecule being reactive substrate for electrophilic reaction and the ortho and/or para positions to the hydroxyl group being first attacked by O 3 and ·OH. Besides, as the steric effect of para position is not as obvious as that of ortho position, phenol was rapidly turned into hydroquinone and a small quantity of catechol with O 3 and ·OH; then hydroquinone turns into p -benzoquinone rapidly by dehydro reaction. Third, the above intermediates decrease and through ring opening, furtherly oxidized into fumaric acid, maleic acid, oxalic acid and formic acid which were finally turned into CO 2 and H 2 O. Over all, the whole reaction process of p -chlorophenol under US/O 3 could be described as follows follows : CONCLUSION 1 US/O 3 was proven to be more effective than both individual sonolysis and ozonolysis in the decomposition of p -chlorophenol. The reaction follows apseudo-first-order kinetics. Under US/O 3 , individual ozonolysis and individual sonolysis, the pseudo-first-order reaction rate constant for p -chlorophenol removal was 0.1225±0.00519 min −1 , 0.07291±0.00353 min −1 , 0.00231±0.00002 min −1 while its CODcr pseudo-first-order reaction rate constant was 0.02799±0.00234 min −1 , 0.00800±0.00007 min −1 , 0.000299±0.00001 min −1 . The enhancement factors of p -chlorophenol and its COD cr under US/O 3 system reach 61% and 237% respectively. Under US/O 3 system, chlorine groups were first removed, which resulted in phenol. Phenol was further decomposed to form hydroquinone and a small quantity of catechol by the electrophilic reaction with ozone and ·OH, and hydroquinone turned into p -benzoquinone rapidly. As the reaction proceeded, these intermediates were further oxidized and the several ring openings that occurred, resulted in the formation of fumaric acid, maleic acid, oxalic acid and formic acid, which finally led to the production of CO 2 and H 2 O. References CD Adams , PA Scanlan , NS Secrist . Oxidation and biodegradability enhancement of 1,4-dioxane using hydrogen peroxide and ozone . Environ Sci Technol , 1994 . 28 1812 - 1818 . . Oxidation and biodegradability enhancement of 1,4-dioxane using hydrogen peroxide and ozone H Bader , J Hoigné . Determination of ozone in water by the indigo method . Wat Res , 1981 . 15 449 - 456 . . Determination of ozone in water by the indigo method E Dahi . Physicochemical aspects of disinfection of water by means of ultrasound and ozone . Wat Res , 1976 . 10 677 - 684 . . Physicochemical aspects of disinfection of water by means of ultrasound and ozone H Destaillats , AJ Colussi , JM Joseph , MR Hoffmann . Synergistic effects of sonolysis combined with ozonolysis for the oxidation of azobenzene and methyl orange . J Phys Chem A , 2000 . 104 8930 - 8935 . . Synergistic effects of sonolysis combined with ozonolysis for the oxidation of azobenzene and methyl orange EPA (Environment Protection Bureau) Standard Methods for the Examination of Water and Wastewater , 1989 . : Washington DC American Public Health Association , 4 - 162 . . Standard Methods for the Examination of Water and Wastewater S Guittoneau , JP Duguet , C Bonnel , M Dore . Oxidation of parachloronitrobenzene in dilute aqueous solution by O 3 +UV and H 2 O 2 +UV: A comparative study . Ozone Sci Eng , 1990 . 12 73 - 94 . . Oxidation of parachloronitrobenzene in dilute aqueous solution by O3+UV and H2O2+UV: A comparative study EJ Hart , A Henglein . Sonolysis of ozone in aqueous solution . J Phys Chem , 1986 . 90 3061 - 3062 . . Sonolysis of ozone in aqueous solution JW Kang , MR Hoffmann . Kinetics and mechanism of the sonolytic destruction of methyl tert-butyl ether by ultrasonic irradiation in the presence of ozone . Environ Sci Technol , 1998 . 32 3194 - 3199 . . Kinetics and mechanism of the sonolytic destruction of methyl tert-butyl ether by ultrasonic irradiation in the presence of ozone A Mokrini , D Oussi , S Esplugas . Oxidation of aromatic compounds with UV radiation/ozone/hydrogen peroxide . Water Sci Technol , 1997 . 35 ( 4 ): 95 - 102 . . Oxidation of aromatic compounds with UV radiation/ozone/hydrogen peroxide TM Olson , PF Baraier . Oxidation kinetics of natural organic matter by sonolysis and ozone . Wat Res , 1994 . 28 ( 6 ): 1383 - 1391 . . Oxidation kinetics of natural organic matter by sonolysis and ozone GR Peyton , WH Glaze . Destruction of pollutants in water with oxone in combination with ultraviolet radiation. 3. Photolysis of aqueous ozone . Environ Sci Technol , 1988 . 22 761 - 767 . . Destruction of pollutants in water with oxone in combination with ultraviolet radiation. 3. Photolysis of aqueous ozone RA Sierka , GL Amy . Catalytic dffects of ultraviolet light and/or ultrasound on the ozone oxidation of humic acid and trihalomethane precursors . Ozone Sci Eng , 1985 . 7 47 - 62 . . Catalytic dffects of ultraviolet light and/or ultrasound on the ozone oxidation of humic acid and trihalomethane precursors J Staehelin , J Hoigné . Decomposition of ozone in water: Rate of initiation by hydroxide ions and hydrogen peroxide . Environ Sci Technol , 1982 . 16 676 - 681 . . Decomposition of ozone in water: Rate of initiation by hydroxide ions and hydrogen peroxide DL Xi , YS Shun , XY Liu . Environmental Mensuration , 1989 . : Beijing China Publishing Company of Higher Education , (in Chinese) . Environmental Mensuration 10.1631/jzus.2005.B0553 2005-01-21 2005-02-21 2005-05-22 2022-01-05 Copyright © 2005, Journal of Zhejiang University Science 2005 Journal of Zhejiang University-SCIENCE B (Biomedicine and Biotechnology) 06 6B